Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Generals
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Trunk - Water Leaks
- A/T - New ATF DW-1 Available
- Recall - Combination Light Switch/Headlamp Wiring Repair
- Campaign - OPDS Unit Warranty Extension
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Recall - Driver's Air Bag Over-Pressurization
- Recall - Replacement Driver Air Bag Over-Pressurization
- Engine Controls - MIL ON/DTC P0128 Is Stored In Memory
- Fuel Sys. - CNG Fuel Tank In-Warranty Exchange Program
- Keyless Entry - Keyless Remote Transmitter Information
- Recall 11V260000: Potential Replacement Air Bag Defect
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- Brakes - Front Squeal, Moan or Grind
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- Instruments - Fuel Gauge Inaccurate on an Incline
- Gauges - Eratic Gauges Or Odd Odometer Display
- Maintenance Required Indicator Doesn't Reset
- Fuel Gauge and Low Fuel Indicator Accuracy Check
- A/C - System Performance Testing
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine Cranking Or Starting Problems After Fill-up
- Engine Won't Start - Check Alternator Bolts
- Cooling Intermittent Overheating/High Temp Gauge Reading
- Engine Controls - PCM Software Can Cause DTC P0128/P1486
- Steering Wheel - Feels Stiff/Grinding Noise When Turning
- Recall - Fuel Pump Connector Corrosion
- Recall 01V183000: Fuel Pump Defect
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- A/C - New Grease for Compressor Thermal Protector
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Engine Rear Main Oil Seal - Leaks
- Suspension - Rear Suspension Squeaking Noises
- Suspension - Lower Ball Joint Replacement
- Front Suspension - Popping/Crunching/Knocking Noise
- Body - Front Bumper Spoiler Loose/Detached
- Body - Front Air Spoiler Loose/Coming OFF
- Headliner - Sags in Rear
- A/T - Leak From Cooler Line Banjo Bolt
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- Campaign - CVT Shift Solenoid Replacement
- A/T - MIL ON/DTC P0740 Set
- A/T - Do Not Remove Torque Converter From Mainshaft
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Drivetrain - Revised CV Joint Boot Band/Installation
- Alternator - Bolt Tightening Sequence Manual Update
- Fuel System - CNG Fuel Tank Venting Procedure Update
- Fuel Tank Manual Lock Down
- Recall - Air Cleaner Housing Inspection/Replacement
- Recall 01V329000: Air Cleaner Box Inspection/Replacement
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Body - Power Windows Inoperative/Intermittent Operation
- Key Beeper, Light Chime and Ceiling Light Don't Work
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Driver's Air Bag - Replace Torx Bolts Properly
- Recall 04V086000: Headlamp Switch/Connector Defect
- Engine - Crankshaft Pulley Service Manual Revision
- Suspension - Front Suspension Knock, Pop or Squeak
- Suspension - Drifting and Pulling At Highway Speeds
- Special Tool - Chassis EAR(TM), Diagnostic Tool
- Body - Water Leaking Into Trunk
- Interior - Center Lower Cover Removal, Manual Revision
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Dashboard Center Lower Cover Sticks Out
- Air Fresheners - Bad News For Paint Or Plastic
- Water Leak From Door. Check Rain Protector
- Wind Noise - Simple Way To Replicate
- Audio Unit - Electronically Retrieving Serial Numbers
- Audio Unit - Models Which Are Electronically Retrieval
- Supplemental Restraint System - Inspection
- Fuel Filler Cap Adapter Available For Testing Emissions
- Engine Controls - DTC Capture and Downloading
- Clearing DTCs and Setting ECM/PCM With The HDS
- Electrical - DTC P1298 Stored in ECM/PCM
- Engine Controls - DTC P0171 Set
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Hood - Rattles on Rough Roads
- Windshield Washer Nozzle Troubleshooting
- Front Door Panel - Rattle/Wind Noise
- Windshield - Cracks At Lower Corners
- Body - Front Window Moves Slowly or Binds
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- Brake Pedal - Click Or Pop When Depressed
- A/T - Shudder/Judder/Shock/Surging
- A/T - In-Warranty Exchange Program
- A/T - DTC P0740 and P0741 Repair Tip
- A/T - Don't Test Drive With The MIL Or D Indicator On
- M/T Mainshaft Reassembly Manual Revision
- M/T - Grinds Shifting To 3rd Gear
- Instruments - Low Fuel Indicator, Manual Revision
- Fog Light Lens - Cracked/Damaged
- SRS - Indicator ON with No SRS DTC Set
- Wiring Terminal - Repair Instructions
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Power Windows Slow - Check Run Channel Friction
- Body - Trunk Release Handle Inoperative
- Interior - A-Pillar Trim Rattles
- Audio System - Never Play CD's With Adhesive Labels
- Paint - 2001 Paint Codes
- Recall - Fuel Fill Hose Clamp Tightness
- Body/Frame - Universal Subframe Removal Adapter
- M/T - Stiff Shifting/Pops Out Of Gear
- Interior - Right Hand Dashboard Creaking Noise
- Ignition Keys Gets Warm While Driving
- M/T - Shift Lever Difficult to Move/Hard Shifting
- Recall 01V380000: Rear Seat Belt Buckle Defect
- Recall - Rear Seat Belt Buckle Non-Compliance
- A/C, Dash - Center Vents Hard to Adjust
- Body - Moonroof Seal Squeaks
- Rear Power Door Locks - Will Not Cycle
- Emissions - MIL ON With DTC P1457 (EVAP) Set
- Restraint System - SRS Indicator ON/DTC's Set
- Restraint System - 'SIDE AIRBAG OFF' Indicator is ON
- Recall 01V182000: Fuel Filler Neck Defect
- Restraints - Child Seat Anchor Locating Button Missing
- Body - Roof Molding Warped/Loose
- Body - Plastic Body Clip Removal Tips
- Tires - Tubless Tire Repair Information
- Emissions - EVAP Testing Using The PGM Tester
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Recall 07V512000: CNG Fuel Tank Insulator Installation
- Emissions - MIL ON/DTC P1457 Set
- Campaign - A/T, CVT Start Clutch Warranty Extension
- Campaign - A/T, CVT Drive Belt Warranty Extension
- Recall - Installation Of Fuel Tank Thermal Insulator
- Recall 08V593000: Air Bag Inflator Replacement
- CNG Fuel System - Fuel Receptacle Check
- Body - Windshield Moulding Warped/Deformed
- Fuel System - CNG Fuel Tank/Line Inspection
- Recall 09V259000: Air Bag Inflator Replacement
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- A/C - Heater Blows Cool Air At Idle
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Recall 10V041000: Air Bag Inflator Replacement
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Fuel System - FTP Sensor Diagnostics/DTC P0497
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Restraints - Pass. Air Bag Replacement BULLETIN CANCELLATION
- Recall 13V132000: Passenger Air Bag Defect
- Antitheft - Immobilizer System (Type 3) Information
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Fuel System - CNG Fuel Tank Solenoid Valve Replacement